Intel SC5000 Bedienungsanleitung

SC5000 Rack Kit Installation Guide Order Number: 7 49354-002[...]

Disclaimer Intel Corpora tion (Intel) m akes no warr anty of any kind with reg ard to this material, inc luding, but not limited to, the implied warranties of m erchantab ility and f itness for a particular purpose. Int el assum es no responsibi lity for any errors that may ap pear in this document. Int el makes no commitm ent to update nor to keep[...]

iii Contents Safety Guidelines Server Prec auti ons ............................................................................................................... 5 Equi pment R ack P reca ution s ............................................................................................... 6 Rack Installat ion Procedures Kit C onten ts .........[...]

iv SC5000 Rack Kit Installa tion Guide[...]

5 Safety Guidelines Before you re move a serve r cover, observe the se safety g uidelines : • Only technically qualified person nel should inte grate the server . • Turn off a ll periph eral devic es connected to the ser ver. • Turn off the server u sing the push-butt on on/off powe r switch on the fron t panel of t he serv er, and unplug the[...]

6 SC5000 Rack Kit Installa tion Guide CAUTIONS E LECTROSTATIC DISCHARGE (ESD) AND ESD PROTECTION : ESD can damage disk d rives, add- in board s, and other components. This serve r can withstand nor mal leve ls of environm ental ESD whil e hot-sw apping SCSI hard disk dr ives. However, we r ecommend d oing all p rocedures i n this manual o nly at an[...]

Safety Guide lines 7 O VERCURRENT PROTECTION : The server is de signed for an A C line voltage so urce with up to 2 0 ampere s of overcurrent p rotection. If the power syste m for the equ ipment rack is installed on a branch ci rcuit with more than 20 ampere s of protect ion, you mu st provide supplemental prot ection for the server. I f more than [...]

8 SC5000 Rack Kit Installa tion Guide[...]

9 Rack Installation Procedur es This manu al descri bes the proc edure to conv ert an SC5000 ch assis fro m the p edestal co nfigurat ion to the rack c onfigu ration. It supp lemen ts the Intel ® SC5000 Server Chassis Subassembly Pr oduct Guide (744708-003). In the fo llowing proc edures, chas sis direc tions (to p, botto m, left, right) re fer to[...]

10 SC5000 Rack Kit Installa tion Guide Remove Feet 1. Place th e chassis on a workb ench so the feet han g over the s ide. 2. Remove th e four screw s (Figur e 1, A) that a ttach the rea r foot to the chassis and remove the foot. 3. Remove th e four screw s that ho ld the front foo t to the cha ssis and re move th e foot. OM09378 A Figure 1. Remo v[...]

Rack Ins tallation Proced ures 11 Remove Top Cover 1. Loosen the two t humbscrews that atta ch the top co ver to the c hassis. 2. Slide th e cover backwa rd a short d istance, un til it s tops. 3. Pull the ent ire cover o utward, s traight awa y from th e chassis, to disengage the rows o f tabs from th e notches i n the to p and botto m edges o f t[...]

12 SC5000 Rack Kit Installa tion Guide Remove 5 ¼-Inch Devices 1. Disconnec t the data a nd power cable s from th e device. 2. Remove and save the two screw s that hold the slide ra ils to the chassis. OM09381 A B C Figure 3 . Removing a 5 ¼ -inch Devi ce A. Power cable B. Data cable C. Slide rail[...]

Rack Ins tallation Proced ures 13 3. Remove and save the two screw s that attach the slide rai ls to the device. OM09383 Figure 4. Removing Slide Rails[...]

14 SC5000 Rack Kit Installa tion Guide Remove Door 1. Move the chas sis so the d oor hangs over the edg e of your workb ench. 2. Open the door. 3. Press th e plastic cl ip (Figu re 5, A) in tow ards the chassis. 4. Pull the hing e pin (F igure 5, B) out with one hand wh ile suppor ting the doo r with th e other. 5. Slide the door to the left to rem[...]

Rack Ins tallation Proced ures 15 7. Remove and save the fou r screws at taching the hinge p late to the chassis. 8. Remove th e hinge p late. OM09380 Figure 6. Removing the Hinge Plate[...]

16 SC5000 Rack Kit Installa tion Guide Remove Bezel 1. Press th e tab up (Figu re 7, A). 2. Slide the beze l to the right. 3. Remove th e bezel from the c hassis . OM09382 A Figure 7. Removing the Bezel A. Tab[...]

Rack Ins tallation Proced ures 17 Remove EMI Covers 1. Remove and save the two screws that at tach the EMI covers to the chassis . 2. Remove all o f the EMI cove rs. There wi ll be one th in cover and up to three w ider cov ers. Do not remove a ny of the ha rd drive ca rriers. OM09376 A Figure 8. Remo ving t he EMI Co vers A. EMI covers[...]

18 SC5000 Rack Kit Installa tion Guide Remove Right Side Cover 1. Remove and save the sc rew at the rear of the c hassis (Fi gure 9, A). 2. Pull up on the black c lip (Figure 9, B). 3. Remove and save the bla ck clip (F igure 9, C). 4. Slide th e cover backwa rds and rem ove it (Fig ure 9, D). OM09390 A C B D Figure 9. Removing the Right Side Cover[...]

Rack Ins tallation Proced ures 19 Install Right Side Cover 1. Slide th e new cover in to position (Figur e 10, A). 2. Insert the black c lip (F igure 10, B). 3. Press the cl ip down (F igure 10, C ). 4. Insert and tighten the screw you removed ea rlier (F igure 10, D ). OM09391 D A B C Figure 10. Installing the Right Side Cover A. Slide the cov er [...]

20 SC5000 Rack Kit Installa tion Guide Install 5 ¼ -Inch Devices into the Reorientation Bracket 1. Remove th e two screws th at hold the EMI shiel d in plac e. 2. Remove th e EMI sh ield. 3. Slide th e device into the b racket. 4. Insert and tigh ten the four screws removed when you removed the sl ide rails. OM09392 C A B D Figure 11. Installing 5[...]

Rack Ins tallation Proced ures 21 Install the 5 ¼ -Inch Reorientation Bracket 1. Slide th e bracket i nto the cha ssis. 2. Insert and tigh ten five screws. 3. Connect data an d power cable s to the dev ices. OM09393 A C B Figure 12. In stallin g the 5 ¼ -Inch Reorientation Bracket A. Screw B. Data cable C. Power cab le[...]

22 SC5000 Rack Kit Installa tion Guide Install Bezel 1. Position the chassis i ntrusion sw itch lo ck. 2. Using a Ph ilips sc rewdriv er, rot ate the sw itch loc k ½ turn clo ckwise. OM09385 D A B C Figure 13. In stalling the Ch assis Int rusion Lock A. Philips s crewdriver B. Cha ssis i ntru sio n swit ch lock C. Direction of rotation D. Chassi s[...]

Rack Ins tallation Proced ures 23 3. Position the bezel. Mak e sure a ll of the p lastic tabs are al igned with t heir holes. 4. Slide i t to the le ft. OM09384 A Figure 14. Installing t he Bezel A. Tab[...]

24 SC5000 Rack Kit Installa tion Guide Install Screw Plate 1. Position the Screw Plate. 2. Insert and tighten the four screws you re moved when you re moved the doo r hinge p late. OM09394 A Figure 1 5. Installin g the S crew P late A. Screw[...]

Rack Ins tallation Proced ures 25 Install Front Cover 1. For each 5 ¼ -i nch periphe ral, remov e the co rresponding plastic c over. 2. If you hav e a hot swap bay i nstalle d, remove t hat plastic cover. 3. Position the bezel b y sliding the tabs on t he top und er the beze l. 4. Tighten the thum bscrews. OM09395 Figure 16. Installing the Front C[...]

26 SC5000 Rack Kit Installa tion Guide Install Top Cover 1. Place th e cover so th e tabs go in to the s lots on the server. The cover should b e flush aga inst the chassis. 2. Slid the cove r forwa rd until i t stops. 3. Tighten the tw o cap tive screw s into t he rear of the chassi s. OM09170 Figure 17. Installing the Top Cover[...]

Rack Ins tallation Proced ures 27 Install Rails 1. Using two screws for each handle, attach the handles to the chassi s. OM09375 Figure 18. Installing the Handles 2. Fully extend the ra ils. 3. Remove th e smalle st rai l. 4. Position the rail 5. Insert and tigh ten four screws. B B B B A OM09377 Figure 19. At taching t he Rail to the Ch assis A. R[...]

28 SC5000 Rack Kit Installa tion Guide OM09388 Figure 20. Rails Installed in a Rack ✏ NOTE Your rack may v ary fr om the il lustration. Re fer to your rack docum entation for informat ion specific to your rack 7. Hold the ch assis so th e rails on the chassis en gage the rails in your rack. You wi ll need someone to he lp you a t this po int. 8. [...]

SC5000  b ] c Û +[...]

Intel (Intel) Intel Inte l Intel Inte l ® 2000 Year 2000 Capable † Copyright  2 000, Intel C orporation.[...]

iii   ] <í .................................................................................................................... 5 ................................................................................................................. 6  ] c ' N ........................................................................[...]

iv SC5000[...]

5 ] <í • • • • I/O • (ESD) á u < ¼ ã _ M :  38 85 45 100[...]

6 SC5000 ¼ ã (ESD ) ESD ESD SCSI ESD ESD — ESD ESD CMOS  Û  ¼ ã _ M :  113 250[...]

7 20 20 350 1+1 12 ¼ ã 5 ° C (41 ° F) 35 ° C (95 ° F) 2000 Btu[...]

8 SC5000[...]

9  ] c ' N SC5000 Int e l ® SC5000 (744708- 003) ESD ¹ K Ù Y  • • • • • • • 5 ¼[...]

10 SC5000  & î { 1. 2. 1 A 3. OM09378 A 1. A.[...]

11  & J ª 1. 2. 3. OM09379 2.[...]

12 SC5000  & 5 ¼ Å Ì  Û 1. 2. OM09381 A B C 3. 5 ¼ A. B. C.[...]

13 3. OM09383 4.[...]

14 SC5000  & ! ª 1. 2. 3. 5 A 4. 5 B 5. 6. OM09389 B A 5. A. B.[...]

15 7. 8. OM09380 6.[...]

16 SC5000  & õ 5 1. 7 A 2. 3. OM09382 A 7. A.[...]

17  & EMI õ S 1. EMI 2. EMI OM09376 A 8. EMI A. EMI[...]

18 SC5000  & Ç { ª 1. 9 A 2. 9 B 3. 9 C 4. 9 D OM09390 A C B D 9. A. B. C. D.[...]

19 ] c Ç { ª 1. 10 A 2. 10 B 3. 10 C 4. 10 D OM09391 D A B C 10. A. B. C. D.[...]

20 SC5000 Ú 5 ¼ Å Ì  Û c 9a n !   1. EMI 2. EMI 3. 4. OM09392 C A B D 11. 5 ¼ A. 5 ¼ B. C. EMI D. EMI[...]

21 ] c 5 ¼ Å Ì a n !   1. 2. 3. OM09393 A C B 12. 5 ¼ A. B. C.[...]

22 SC5000 ] c õ 5 1. 2. OM09385 D A B C 13. A. B. C. D.[...]

23 3. 4. OM09384 A 14. A.[...]

24 SC5000 ] c S - 1. 2. OM09394 A 15. A.[...]

25 ] c ! ª 1. 5 ¼ 2. 3. 4. OM09395 16.[...]

26 SC5000 ] c J ª 1. 2. 3. OM09170 17.[...]

27 ] c Ð < 1. OM09375 18. 2. 3. 4. 5. B B B B A OM09377 19. A. B. 6.[...]

28 SC5000 OM09388 20. ✏ ¼  7. 8. A OM09374 21.[...]