Harman Stove Company Super Magnum Coal Stoker Stove Bedienungsanleitung

3-90-02702R4_08/12 www .harmanstoves.com Owner's Manual Installation and Operation Model: Super-Magnum Coal Stoker Stove NOTICE • Important operating and maintenance instructions included. • Read, understand and follow these instructions for safe installation and operation. • Leave this manual with party responsible for use and operation[...]

2 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 Hearth & Home T echnologies welcomes you to our tradition of excellence! By choosing a Harman appliance, you have become part of a long standing family committed to meeting the heating needs of consumers with the most distinctive, powerful and responsible home heating pro[...]

3 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 T ABLE OF CONTENTS Section 1: Listing and Code Approvals A. Appliance Certications 4 B. Mobile Home Approval 4 C. Glass Specications 4 D. Electrical Rating 4 E. BTU & Efciency Specications 4 Section 2: Special W arnings and Notes A. Carbon Monoxide W arnings &[...]

4 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 1 Listing and Code Approvals A. Appliance Certication Model: Super Magnum Coal Stoker Laboratory: OMNI-T est Laboratories, Inc. Report No. 135-S-24-6.2 T ype: Solid Fuel Room Heater / Coal Burning T ype. Standard(s): UL1482, UL391, & ULC S627-00 This appliance is also [...]

5 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 NEVER CONNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER APPLIANCE. Installation and repair of this stove should be done by a qualied service person. We recommend that the stove be inspected before use and at least annually by a qualied service person. Periodic cleanin[...]

6 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 3 Getting Started A. Design, Installation & Location Considerations 1. Appliance Location Consideration must be given to safety , convenience, trafc ow , and the fact that the appliance will need a chimney and chimney connector . It is a good idea to plan your insta[...]

7 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 C. Component Locations Load Door Ash Removal Door Distribution Air Filter Distribution Blower Air Grill Heat T ransfer Kit Filler Plate V erti-Flow TM Feeder Control Panel Heat Exchange Cleaning Rod Exhaust Sensing Probe (ESP) Coal Storage Hopper Removable Hopper Lid[...]

8 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 D. Pre- Use Check List 1. Place the appliance in a location near the nal installation and follow the procedures below: 2. Open the appliance and remove all articles packed inside. Inspect all items for shipping damage. Notify dealer of any missing or damaged goods. 3. All [...]

9 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 4 Dimensions & Clearances A. Appliance Dimensions[...]

10 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 B. Clearances T o Combustibles A C D B F E E C D B A Parallel Installation Inches Millimeters Back W all T o Unit Hopper Side W all T o Unit Back W all T o Flue Connector Side W all T o Flue Connector 2 51 17 432 24 610 34 864 F E Corner Installation Inches Millimeters W all[...]

1 1 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 5 Chimneys and V enting A. Draft Draft is widely misunderstood. It is important that you, the stove operator , realize that draft is a variable effect , not a given quantity . Stoves and chimneys do not have draft, yet draft is the key to your stove’s performance. Draft i[...]

12 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 D. The Chimney This unit must be installed into a chimney approved for use with solid-fuel appliances. In the U.S., it must be connected to (1) a prefabricated chimney complying with the requirements for T ype HT chimneys in the Standard for Chimneys, Factory-B uilt, Residen[...]

13 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 Do not burn any fuel other than coal. Never use highly volatile substances in your stove, such as gasoline, which could cause an explosion. When solid fuels are burned completely , they produce water and carbon dioxide. However , in long slow burns, a substantial amount of c[...]

14 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 E. Draft T est Procedure Because of the dangers associated with coal gases and the potential for carbon monoxide release, It is important to balance the airow into the stove with the draft in the ue. The combustion blower has a restrictor plate attached to it, which mu[...]

15 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 6 Mobile Home A. Mobile Home Installation Mobile home approval - U.S. only . 1. An outside air inlet must be provided for combustion air , and must remain clear of leaves, debris, ice, and/or snow . The outside air path must be unrestricted while the appliance is in operatio[...]

16 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 7 Appliance Set-Up A. Outside Air Attachment Parts and Supplies Needed: 1 piece of metal exible pipe, 3" X needed length. 1 Rodent Screen, Plus, you'll want to obtain a trim ring for nishing around the pipe on the inside wall. 1. Remove the knockout from the [...]

17 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 B. Leveling the Appliance T o adjust the leveling bolts, you must rst loosen the locking nut. T urn the leveling bolt to the desired position, and re tighten the locking nut against the cast iron leg. C. Optional Heat T ransfer Kit The duct piping must be of metal constru[...]

18 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 F . Optional Door T rim Kit The door trim kit includes a brushed stainless frame for each door , and an air grill. T o install the optional door trim, you'll rst need to remove the latch mechanism from the door . The process is the same for each door . 1. Using a hex[...]

19 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 8 Operating Instructions A. Fuel Specications The Super Magnum is designed for use with Anthracite "Rice" coal Only . Anthracite is a hard coal which is mined mostly in the Eastern United States. The post-mining process involves breaking the large lumps of anthr[...]

20 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 Status Light Error Messages 3-Blinks: Indicates that the ESP has gone out of range too many times. Could be an indicator of build up of ash, etc. in the ue pipe or heat exchange. Perform a Manual Reset. 4-Blinks: Indicates that the room sensor circuit is not complete. May[...]

21 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 a. Feed Rate Adjustment The Circuit board runs on a one minute timer cycle. Each minute, the board is thinking ahead to what it needs to do for the next minute to maintain or achieve the demanded temperature. What you are setting on the feed adjuster dial is the maximum amou[...]

22 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 C. Before Y our First Fire • Be sure the appliance is installed properly and that all safety requirements have been met. Pay particular attention to the clearances to combustibles, oor protection and the venting instructions. • T est your smoke detector(s) and CO dete[...]

23 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 Symptom Possible Cause Corrective Action 9 T roubleshooting With Proper installation, operation, and maintenance, your appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualied person in the diag[...]

24 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 10 Service & Maintenance A. Shut-down Procedure The best way to shut down the appliance is to simply let it run out of fuel, and shut down naturally as the temperature cools. This method is highly recommended for the end of season shut-down. T o shut-down otherwise, turn[...]

25 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 2. Heat Exchanger Chain Scraper • Frequency: Daily • By: User Wear Gloves T o Perform Whenever adding coal to the hopper , take the opportunity to clean the heat exchanger surfaces. After all, the cleaner the surface, the better the heat transfer capability . C. General [...]

26 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 3. Fines T ray Emptying • Frequency: Weekly • By: User Wear Gloves T o Perform Fines are small dust-like particles which fall from the feed system during operation. Depending on the fuel being used, this tray may need emptied more frequently . Open the left rear access d[...]

27 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 5. Air Filter • Frequency: Monthly • By: User Filter replacement is recommended every month. Follow the steps below to remove the lter . T urn the mode selector to "OFF" to stop the blower from operating. • Locate and loosen the two thumb screws that hold [...]

Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 28 8. Chimney Connector • Frequency: As necessary / Y early • By: Qualied Service T echnician / User At the end of the burn season, brush and clean all sections of chimney connector pipe. Some owners remove the chimney connector for the of f season. Any coal ashes left i[...]

29 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 3. Distribution Blower Requires no lubrication. Change lter monthly to prevent build up of pet hair , etc. T o remove distribution blower; • Remove lter retainer and lter . • Disconnect the three wires from the blower power cord. • Loosen 3 mounting screws whi[...]

30 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 1 1 Reference Materials 120 V AC SUPPL Y T WISTED WIRES CONTROL THERMOST A T EXTENSION FEED MOT OR MA X. W A T TS 396 -- 3.3A. -- 120 VOL TS A.C. 60 HZ. ROOM SENSOR 6 AMP GLASS FUSE EXHAUST SENSING PROBE BOARD BLACK WHITE BLACK BLACK GREEN LABEL P ART NO. 3-90-02703 11 PIN C[...]

Service Parts Super Mag Stoker Part number list on following page. 1-90-02700-1 Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active 34 33 32 31 30 29 35 37 38 28 26 24 23 39 40 41 43 36 42 20 21 22 19 18 17 1 6 7 8 9 5 2 3 4 27 16 15 14 13 12 1 1 10 25 8/12 Coal Stove[...]

Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM Description COMMENTS P ART NUMBER 1 Scraper Kit 1-00-02770 2 Rear Cover Right Assembl[...]

Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM Description COMMENTS P ART NUMBER 31 1/4"-20 x 1/2" Alloy Steel Black Oxide[...]

Service Parts IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM Description COMMENTS P ART NUMBER 43 Feeder Assembly 1-10-02700A Y 43.1 Pusher Block [...]

Service Parts Super Mag Stoker Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot[...]

4021-645C 12-29-10 Page 1 of 2 Hearth & Home T echnologies Inc. LIMITED LIFETIME W ARRANTY Hearth & Home T echnologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer . W ARRANTY COVERAGE: HHT warr[...]

4021-645C 12-29-10 Page 2 of 2 W ARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor . A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. • Co[...]

38 Super-Magnum Coal Stoker Stove Do Not Burn Wet Coal! 3-90-02702R4_08/12 Service & Maintenance Log Date Of Service Performed By Description Of Service[...]

39 Do Not Burn Wet Coal! Super-Magnum Coal Stoker Stove 3-90-02702R4_08/12 Service & Maintenance Log Date Of Service Performed By Description Of Service[...]

Proudly P rinted On 100% R ecycled P aper At Harman, we build each pr oduct to a standard, not a price . (Signatur e of Box er) Y our premium quality hearth pr oduct designed and assembled by the experienced and skilled members at Harman in Halifax, P A, USA.[...]