Amana RS2320006 Bedienungsanleitung

RS2320006 Revision 0 August 2001 This manual is to be used by qualified appliance technicians only. Amana does not assume any responsibility for property damage or personal injury for improper service procedures done by an unqualified person. Servic e Electric Freestanding BIG OVEN™ Service Manual for Amana ® This manual covers general informati[...]

RS2320006 Rev. 0 2 Important Information Pride and workmanship go into every product to provide our customers with quality products. It is possible, however, that during its lifetime a product may require service. Products should be serviced only by a qualified service technician who is familiar with the safety procedures required in the repair and[...]

3 RS2320006 Rev. 0 Table of Contents Important Information ................................................. 2 Important Safety Information ...................................... 4 ALL APPLIANCES ............................................... 5 SURFACE COOKING UNITS .............................. 5 OVENS ...........................................[...]

RS2320006 Rev. 0 4 Important Safety Information WARN ING ! To a void risk of electrical shock, personal injury, death, or property damage, verify wiring is correct, if components were replaced. Verify proper complete operation of unit after servicing. CAUT ION ! DO NOT TOUCH SURFACE UNITS OR AREAS NEAR UNITS—Surface units may be hot though they a[...]

5 RS2320006 Rev. 0 Important Safety Information SURFACE COOKING UNITS 1. Use Proper Pan Size—This appliance is equipped with one or more surface units of different size. Select utensils having flat bottoms large enough to cover the surface unit heating element. The use of undersized utensils will expose a portion of the heating element to direct [...]

RS2320006 Rev . 0 6 General Information Cooking Utensils • Use proper pan size. Do not use a pan that has a bottom smaller than element. Do not use utensils that overhang element by more than 1 inch. More than 1" overhang 2" Less than 1" overhang 1" • Use care when using glazed cooking utensils. Some glass, earthenware, or o[...]

7 RS2320006 Rev . 0 General Information Follow these recommendations only as a guide for times and temperature. Times, rack position, and temperatures may vary depending on conditions and food type. For best results, always check food at minimum time. When roasting, choose rack position based on size of food item. Oven Rack Placement Position oven [...]

Component Testing Information ! WARNI NG To avoi d risk of electric al shoc k, per sonal inj ury or de ath; disc onnect p ower to o ven bef ore ser vicing, un less testing r equires it. RS2320006 Rev. 0 8 Refer to Technical Sheet or Parts Manu al for replacement components specifications. Illustra tion Comp onent Test Pro cedure Res ults Oven light[...]

Troubleshooting Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven before servicing, unless testing requires it. RS2320006 Rev. 0 9 Problem Possible Cause Correction Surface element does not heat • Open element ..................................... • Loose wire connection or broken wire . [...]

Troubleshooting Procedures ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven before servicing, unless testing requires it. R S2320006 Rev. 0 10 Problem Possible Cause Correction Melted top door trim • Miss - aligned door gasket ..................... • Replace door gasket. • Check door hinges. Self[...]

Disassembly Procedures 11 RS2320006 Rev. 0 To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! Oven Door Handle, Outer/Inner Glass, and Door Hinges 1. Open or remove storage drawer to avoid damaging finish. 2. Fully open the oven door , while open rota[...]

Disassembly Procedures To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! RS2320006 Rev. 0 12 Reverse Procedure to Reassemble Oven Door  Position slot on oven door hinge arms into the hinge receivers. When slot is engaged into the hinge receivers, [...]

Disassembly Procedures 13 RS2320006 Rev. 0 To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! Maintop NOTE: Requires range to be moved out away from the wall. 1. T urn power of f to unit. 2. Slide range forward on slide guards. NOTE: Usage of slide gu[...]

Disassembly Procedures To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! RS2320006 Rev. 0 14 Broil Element 1. T urn of f power to unit. 2. Remove screw securing broil element to rear of oven wall. 3. Remove screws securing element hanging clip to ove[...]

Disassembly Procedures 15 RS2320006 Rev. 0 To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! Storage Drawer Removal 1. Pull drawer out until it stops. 2. Grasp drawer sides near back of drawer and lift up and out. 3. Reverse procedure to reinstall st[...]

Disassembly Procedures To avoid risk of electrical shock, personal injury or death; disconnect power supply source before servicing, unless testing requires it. WA RNI NG ! RS2320006 Rev. 0 16 This page intentionally left blank.[...]

A1 RS2320006 R ev . 0 Appendix A[...]

RS2320006 Re v . 0 A 2 Installa tion Electric Range PREP ARE T O INST ALL RANGE AND INST ALL ANTI-TIP BRA CKET Measure cabinet area and prepare it according to illustrations in Minimum Clearances to Combustible Surfaces and Range and Cabinet Dimensions section in this manual. Remove the packing materials and locate the anti-tip bracket, screws, [...]

A3 RS2320006 R ev . 0 CONNECT ELECTRICAL CORD T o place electrical receptacle, see Electrical Receptacle Location diagram in this manual. 2 3-wir e or 4-wire Plug Connection Four-wire cord is required for mobile homes or where codes (Canada) do not permit grounding through neutral. 1. Remove access cover from rear of range. 2. Use a strain relie[...]

RS2320006 Re v . 0 A 4 POSITION AND LEVEL RANGE Place range near final position and plug in. Then, slide range into final position and adjust all legs (4) until range is level side to side and front to back.  Place a level on top oven rack or on range top when leveling.  Leveling legs must extend ¼" to engage anti-tip bracket. 3 Remo[...]

A5 RS2320006 R ev . 0 Bef ore Y ou Install Installation Requirements Consider Descri pt i on Location This r ange can be i nstal l ed fl ush against ri ght and lef t base cabi nets, and rear ver ti c al w all . R ange can also be i nstal led f l ush aga i nst l eft or ri g ht vert i ca l w all ext end i ng above 3 6" st andard countert o p [...]

RS2320006 Re v . 0 A 6 Range and Cabinet Dimensions Electrical Receptac le Location Locate electrical receptacle in area with diagonal lines.              [...]

A7 RS2320006 R ev . 0 Important Safety Information SA VE THESE INSTR UCTIONS WARNING ! T o avoid risk of the appliance tipping, it must be secured by a properly installed anti-tip bracket. T o make sure bracket has been inst alled properly , remove the storage drawer or p anel and look under the range with a flashlight. Bracket must be engaged i[...]

RS2320006 Re v . 0 A 8 This page intentionally left blank.[...]

B1 RS2320006 R ev . 0 Appendix B[...]

RS2320006 Re v . 0 B 2 Care and Cleaning R emo ving Ov en Door 1. Fully open oven door . 2. Push hinge locks down toward door frame, to the unlocked position.  This may require a flatblade screwdriver . 3. Firmly grasp both sides of top of oven door . 4. Close door to first stop position. 5. Lift door up until hinge arm is clear of the slot. [...]

B3 RS2320006 R ev . 0 T o keep your smoothtop looking like new , Amana recommends routine cleaning. The following general instructions for routine and tough spot cleaning are based on the performance of Amana recommended product s. T o order these products, contact the Consumer Affairs dep artment at 800-843-0304. Re placing Oven Light 1. Discon[...]

RS2320006 Re v . 0 B 4 PROBLE M CAUSE REMOVAL Brown str eaks and specks Cleani ng with spon ge or cl oth c ontai ning soil ed deter gent water . Normal cl eansin g (provi ded above) . Blackened, burnt on spots Spatt ers or spi llov ers on a h ot cook ing ar ea or acci dental melt ing of plast ic l ike a bread bag. Clean ar ea with smoot htop c l[...]

B5 RS2320006 R ev . 0 Care and Cleaning Can I use liquid cleaners on my stainless steel? Just because a cleaner is a liquid does not mean it is non-abrasive. Many liquid cleansers designed to be gentle on tile and smooth surfaces still damage stainless steel. Cosmetic damage from using non-recommended products is not covered under warranty . F o[...]

RS2320006 Re v . 0 B 6 This page intentionally left blank.[...]

C–1 RS2320006 Rev . 0 Appendix C[...]

Genesis Control Testing Information ! WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven before servicing, unless testing requires it. RS2320006 Rev. 0 C − 2 Mylar Overlay  KRC OVEN PREHEAT LOCKED PUSH TO TURN BAKE OVEN CLEAN OFF WM BROIL LIGHT TIMER ON OFF COOK CLEAN TIME START COOK CLEAN OVEN TEMP C[...]

Genesis Control Programming Instructions C − 3 RS2320006 Rev. 0 Setting Electronic Clock The 12 ho ur clock does not display AM , PM or military time. When power is connected or restored, display flashes until RECALL OVEN TEMP/CLOCK pad is pressed or temperature knob is turned. 1. Press RECALL OVEN TEMP/CLOCK pad. 2. Press appropriate slew pads u[...]

Genesis Control Programming Instructions RS2320006 Rev. 0 C − 4 7. Oven will automatically begin to heat at selected start time. • OVEN ON light will turn on when oven begins t o heat. • To adjust cook time, press COOK/CLEAN TIME pad twice while the remaining cook time is displayed. Cook time can then be adjusted. • When cooking time has el[...]

D–1 RS2320006 Rev . 0 Appendix D[...]

Sigma Control Testing Information ! WARNI NG To avoi d risk of electric al shoc k, per sonal inj ury or de ath; disc onnect p ower to o ven bef ore ser vicing, un less testing r equires it. RS2320006 Rev. 0 D 2 Sigma Touc hmatic elect ronic r ange cont r ol CLOCK OVEN LI GHT COOK STOP TIMER START OVEN CANCE L ON/O FF BAKE CL EAN BROI L 1 2 3 4 5 6 [...]

Sigma Control Testing Information ! WARNI NG To avoi d risk of electric al shoc k, per sonal inj ury or de ath; disc onnect p ower to o ven bef ore ser vicing, un less tes ting requires it. D 3 RS2320 006 Rev. 0 Illustra tion Comp onent Test Pro cedure Res ults ERC Controll ed Temperat ure adjust ment (BAKE mode onl y) Press BAKE pad. Press in oven[...]

Sigma Control Programming Instructions D 4 RS2320 006 Rev. 0 Setting Electronic Clock 12 hour c lock does not dis play AM , PM or m ilitar y tim e. W hen power is c onnected or restor ed, disp la y flashes until CLO CK or CA NCEL pad is pres sed. 1. Press CLOCK pad. 2. Press digit pads (1 throu gh 0) until cor rec t time-of-da y displays. 3. Press [...]

Sigma Control Programming Instructions RS2320006 Rev. 0 D 5 Delayed Baking Set oven t o begin a nd end b aking at a lat er tim e. Oven control automatic all y calculates starting t im e. 1. Place food in o ven. 2. Pres s STO P TIME butt on. • Default tim e displ ayed is current t ime of day. 3. Use the digit pads (1 through 0) to enter the desir [...]